Inactive
Notice ID:N4523A22R1050
The Northwest Regional Maintenance Center at Puget Sound Naval Shipyard & Intermediate Maintenance Facility (PSNS & IMF) is conducting market research to determine industry capability and interest in ...
The Northwest Regional Maintenance Center at Puget Sound Naval Shipyard & Intermediate Maintenance Facility (PSNS & IMF) is conducting market research to determine industry capability and interest in the docking of and performance of maintenance, repair and preservation work in support of Caisson 1. All work shall be accomplished at the Contractor's facility. Special Note: Contractor’s facility must be capable of dry-docking the vessel in order to accomplish all required work. Vessel Characteristics Length of 94 FT 10-3/8 IN Height of 39 FT Draft of 20 FT 11-7/16 IN Width of 16 FT Light Load Displacement 762 L Tons Full Displacement 1,483 L Tons Hull Type is Steel Geographical Area of consideration: To facilitate proper government oversight, the facility shall be located in the Puget Sound, WA region. For this procurement, the Puget Sound, WA region is defined as the West Coast of the continental US, starting from Olympia, WA and extending northward to Bellingham, WA. The Government is seeking responses from sources that can perform the following work: Coordinate with the Contracting Officer, via the Contracting Officer’s Representative (COR) to deliver the vessel to the Contractor’s facility. Dock, wash, and clean the exterior surfaces of the vessel upon docking. Blast & preserve Hull Exterior. Hull corrosion weld repairs. Control Hazardous Waste. Replace rubber seals and hardware. UT rubber seal steel mating surface. Perform visual and ultrasonic Inspections of the hull, tanks, weather deck, drainage piping, and ballasting system. Pump and clean tanks. Repair hatches on the Weather Deck and the Operations Deck. Install Mimic Board. Test Alarm Systems and Associated Equipment. Clean Ventilation System. Replace Valves. Install Super-flood Pump Discharge Piping Covers. Replace Dewatering Pumps and Motors. Renew Valve Stem Extension Assemblies. Replace Grease Lines and Steady Bearings. Replace Actuator Stands and Actuators. Remove and inspect Rubber Fendering. Install Handrail Swing Gate. Renew Boarding Ladder. Blast and preserve Tanks, Operational Deck Compartment, Handrail Stanchions, and Hull. Replace Non-Skid. Support Operational Testing. Replace Hull and Tank zincs. Undock the vessel. Arrange and coordinate the delivery of the vessel back to the Government with the Contracting Officer via the COR. The Estimated Period of Performance for this potential requirement is estimated at 120 days. For planning purposes, the Period of Performance shall commence between 1 June 2022 and 1 September 2022. The actual Period of Performance shall be negotiated/proposed if a solicitation is released for this requirement. This notional schedule is provided for planning purposes only. The Government is not obligated to pursue this schedule or a future solicitation as a result of this sources sought. What/Where to Submit: Interested companies should submit, on company letterhead, a notice of interest including the name, Cage Code, DUNS number, telephone number, mailing address and e-mail address of a minimum of one point of contact. Please hand or digitally sign your letter of interest and e-mail it to the Government contacts listed below, with "Caisson 1 - Sources Sought Response" in the subject field. Brian Fergus Contract Specialist brian.fergus@navy.mil 360-476-4071 Chris Campbell Contracting Officer chris.campbell@navy.mil The notice of interest should include a brief description of your company and its capabilities. There is no page limit or specific formatting required for your response; however, please only submit a response in Microsoft Word of Adobe PDF file types. Specifically, please address the following questions below: Your Company must be successfully capable of dry-docking the vessel and have demonstrated this ability within the past 36 months. This vessel is estimated in excess of 760 L tons and has a draft of 21 FT. Please provide a generalized dry docking plan with specifications regarding the dry docking capability of all equipment or combination thereof. The plan should be detailed enough to demonstrate that your company will reasonably dry dock the vessel. Please provide relevant examples within the past 36 months of similar sized vessels your company has dry-docked. The government may contact your company with follow-up questions and/or request additional materials as part of market research efforts about potential facilities in the area of consideration. Is your company a small or large business as defined by the Small Business Administration (SBA) under NAICS code 336611 (a small business must have 1,250 or less employees)? Does your company have a satisfactory performance record for the type of work required? Please provide examples of relevant and recent (within three years) past performance. Does your company have the necessary organization, experience, accounting and operational controls and technical skills or the ability to obtain them (including, as appropriate, such elements as production control procedures, property control systems, quality assurance measures and safety programs applicable to materials to be produced or services to be performed by the prospective contractor and subcontractors)? Given the work described in this announcement, does your company plan to submit a proposal in response to the anticipated solicitation for the Caisson 1 package? When to Submit: Responses are requested no later than Close of Business, on 18 August 2021. Responses will be reviewed as they are received. Notice Regarding Sources Sought: This sources sought is issued solely for information and planning purposes - it does not constitute a Request for Proposal (RFP) or a promise to issue an RFP in the future. This sources sought does not commit the Government to contract for any supply or service whatsoever. Further, the Navy is not seeking proposals at this time, nor accepting unsolicited proposals. Responders are advised that the U.S. Government will not pay for any information or administrative costs incurred in response to this sources sought; all costs associated with responding to this sources sought will be solely at the interested party's expense. Not responding to this sources sought does not preclude participation in any future RFP, if any is issued. If a solicitation is released, it will be synopsized on the SAM.GOV (https://sam.gov) website. It is the responsibility of the potential offerors to monitor these sites for additional information pertaining to this requirement. Information provided shall be treated as Business Sensitive or Confidential to the responder, exempt from public release under the Freedom of Information Act. PSNS & IMF may request further information regarding the capabilities of respondents to meet the requirements set forth in the announcement. This sources sought announcement is released in accordance with FAR 15.201. Information provided in response to this sources sought announcement will not be considered an offer by the responding contractor and cannot be accepted by the Government to form a binding contract.
